Brake upgrade

As the Audi A4 B6 standard car is not known for its awesome brakes, I figured it was time for a brake upgrade.

I spent some considerable time researching brake upgrades for the car and after a while landed on a set up that wouldn’t cost a years pay (read big brake upgrade) while still providing a big improvement in braking performance. I managed to track down a set of callipers and brackets from an 2006 A4 B7 2.0T avant witch had the 320mm front disks. These are bolt on replacement callipers for the A4 B6 which fits the project perfectly. In addition to the callipers, I bought a set of yellow-stuff brake pads and slotted 321mm ventilated disks produced by EBC. Since then, I’ve heard that people have had bad experiences with the yellow-stuff brake pads but I decided to give them a try and see how they behave. I also bought a new set of Bosch rubber brake lines to compliment the new callipers.

As of tonight, I replaced the right side brakes before i got hungry and decided to get some food. The brakes fitted perfectly and bolted on without issues.

I’ll update after I’ve done a test-run with both sided replaced.

Update: Finished replacing and bleeding the front brakes and took it for a test run. Unfortunately, it was snowing, so I couldn’t do any hard brake tests, but I drove it for a good half an hour to get the protective film off the disks and pads. It seems to work pretty well and I defiantly noticed an improvement over the standard disks and pads. I took it out for a ride a few days later and noticed that the brakes has reduced performance when cold – this was expected though, and shouldn’t be a problem.

All in all, very happy with the upgrade. Time to make a plan for replacing the rear as well. I’ll write down the part numbers in case someone would like to do the same upgrade.

Calipers: 4F0615123 (left) and 4F0615124 (right)
Disks: EBC USR1423
Pads: EBC DP41495R (EBC yellowstuff)

Link to the shop – shop.brakes.no

Leave a Reply

Your email address will not be published. Required fields are marked *